硅酸盐学报

短期持压荷载与混凝土内水分传输的耦合过程

作者：鲍玖文王立成程宝娟

分类号：TU528

出版年,卷(期):页码：2016,44(8):1154-1160

DOI：10.14062/j.issn.0454-5648.2016.08.11

摘要：

荷载与环境因素的耦合作用影响着混凝土内物质传输过程和混凝土结构的服役寿命。为实现短期持续加载和混凝土内水分传输的耦合作用，基于改进的混凝土吸水实时测量装置，对中空圆柱体混凝土试件持续受压加载32 h的同时，按规定时间间隔记录水平观测管内水柱长度的变化，测得混凝土累积吸水量曲线，开展了短期持压荷载作用下低应力水平(0~50%)对混凝土毛细吸水性能影响分析，并根据试验结果建立了相对吸水率与体应变关系。基于扩展Darcy定律的非饱和流体理论(UFT model)，采用指数和幂函数两种形式的水力扩散系数，开展了不同应力水平下混凝土中水分分布的预测分析。结果表明：短期持压荷载对混凝土的毛细吸水性能影响显著；在0~50%应力水平范围内，随着应力水平的提高，混凝土的累积吸水量和初始吸水速度先减小后增大，而后期吸水率和水分侵入深度单调增加；根据UFT模型计算的水分渗透深度预测值与实际观测值吻合较好。

Mass transport process and service life of concrete structures are affected by the coupling of loading and environmental conditions. In order to realize the coupled effect of short-term sustained loading and water absorption process within concrete, the capillary absorption of the hollow cylinder specimens at different compressive stress levels for 32 h was investigated by an improved device for real-time measurement of cumulative absorbed water. According to the cumulative water absorption curve measured by the water length variation through the horizontal observation tube, the effect of low stress levels on the capillary absorption in concrete subjected to short-term sustained compressive loadings was analyzed. The linear quantitative relationship between the relative sorptivity and volumetric strain was discussed based on the experimental results. The water content distribution of concrete at various stress levels, i.e. 0–50%, was predicted by two hydraulic diffusivity functions the exponential-law and power function, based on the unsaturated flow theory (UFT) model of the extended Darcy's law. The results indicate that short-term sustained compressive loadings have a great influence on the capillary absorption of concrete. In the range of stress levels studied currently, the cumulative water content and initial water absorption rate initially decrease and then increase, and the secondary sorptivity and water penetration depth monotonously increase with the increase of stress level. Moreover, the predicted data of water penetration depth obtained by UFT model are similar to the experimental results.

基金项目：

国家自然科学基金面上项目(51378090)；国家重点基础研究发展计划(973计划)(2015CB057701；2015CB057703)。

作者简介：

鲍玖文(1989—)，男，博士研究生。

参考文献：

[1] 方永浩, 李志清, 张亦涛. 持续压荷载作用下混凝土的渗透性[J]. 硅酸盐学报, 2005, 33(10): 1281–1286.
FANG Yonghao, LI Zhiqing, ZHANG Yitao. J Chin Ceram Soc, 2005, 33(10): 1281–1286.
[2] TEGGUER A D, BONNET S, KHELIDJ A, et al. Effect of uniaxial compressive loading on gas permeability and chloride diffusion coefficient of concrete and their relationship[J]. Cem Concr Res, 2013, 52: 131–139.
[3] 李春秋, 李克非. 干湿交替下表层混凝土中氯离子传输: 原理、试验和模拟[J]. 硅酸盐学报, 2010, 38(4): 581–589.
LI Chunqiu, LI Kefei. J Chin Ceram Soc, 2010, 38(4): 581–589.
[4] 张东东, 庞晓赟, 李克非. 基于等温吸附的水泥基孔隙材料水分传输过程[J]. 硅酸盐学报, 2015, 43(8): 1024–1031.
ZHANG Dongdong, PANG Xiaoyun, LI Kefei. J Chin Ceram Soc,
2015, 43(8): 1024–1031.
[5] 付传清, 屠一军, 金贤玉, 等. 荷载作用对混凝土中氯盐传输的影响研究进展[J]. 硅酸盐学报, 2015, 43(4): 400–410.
FU Chuanqing, TU Yijun, JIN Xianyu, et al. J Chin Ceram Soc, 2015, 43(4): 400–410.
[6] CHOINSKA M, KHELIDJ A, CHATZIGEORGIOU G, et al. Effects and interactions of temperature and stress-level related damage on permeability of concrete[J]. Cem Concr Res, 2007, 37(1): 79–88.
[7] WANG L, LI S. Capillary absorption of concrete after mechanical loading[J]. Mag Concr Res, 2014, 66(7/8): 420–431.
[8] YANG Z, WEISS W J, OLEK J. Water transport in concrete damaged by tensile loading and freeze–thaw cycling[J]. J Mater Civ Eng, 2006, 18(3): 424–434.
[9] WANG K, JANSEN D C, SHAH S P, et al. Permeability study of cracked concrete[J]. Cem Concr Res, 1997, 27(3): 381–393.
[10] LIM C C, GOWRIPALAN N, SIRIVIVATNANON V. Microcracking and chloride permeability of concrete under uniaxial compression[J]. Cem Concr Compos, 2000, 22(5): 353–360.
[11] SAMAHA H R, HOVER K C. Influence of microcracking on the mass transport properties of concrete[J]. ACI Mater J, 1992, 89(4): 416–424.
[12] RAHMAN M K, AL-KUTTI W A, SHAZALI M A, et al. Simulation of chloride migration in compression-induced damage in concrete[J]. J Mater Civ Eng, 2012, 24(7): 789–796.
[13] 何世钦, 贡金鑫. 弯曲荷载作用对混凝土中氯离子扩散的影响[J]. 建筑材料学报, 2005, 8(2): 134–138.
HE Shiqin, GONG Jinxin. J Build Mater (in Chinese), 2005, 8(2): 134–138.
[14] ASTM. ASTM C1585 Standard test method for measurement of rate of absorption of water by hydraulic-cement concretes[S]. West Conshohocken: American Society for Testing and Materials, 2004.
[15] 彭智. 干湿循环与荷载耦合作用下氯离子侵蚀混凝土模型研究[D]. 杭州: 浙江大学, 2010.
PENG Zhi. Model of chloride penetration concrete under the drying and wetting cycles coupled with load (in Chinese dissertation). Hangzhou: Zhejiang University, 2010.
[16] LOO Y H. A new method for microcrack evaluation in concrete under compression[J]. Mater Struct, 1992, 25: 573–578.
[17] HALL C. Water sorptivity of mortars and concretes: a review[J]. Mag Concr Res, 1989, 41(147): 51–61.
[18] LOCKINGTON D A, PARLANGE J Y, DUX P. Sorptivity and the estimation of water penetration into unsaturated concrete[J]. Mater Struct, 1999, 32(5): 342–347.
[19] 王立成, 鲍玖文, 李淑红. 损伤混凝土毛细吸水性能试验研究和水分分布预测分析[J]. 大连理工大学学报, 2015, 55(6): 597–604.
WANG Licheng, BAO Jiuwen, LI Shuhong. J Dalian Univ Technol (in Chinese), 2015, 55(6): 597–604.
[20] DU X, JIN L, ZHANG R. Chloride diffusivity in saturated cement paste subjected to external mechanical loadings[J]. Ocean Eng, 2015, 95: 1–10.

服务与反馈：

【文章下载】【加入收藏】